Oil Recovery from Oilfield Produced Water Using Zinc Oxide Nano Particle as Catalyst in Batch and Continuous System

• Autorzy: Alkhazraji Hussein Ali Jabbar , Alatabe Mohammed Jaafar Ali

Identyfikatory

DOI

10.12911/22998993/140281

• Języki publikacji: EN

Abstrakty

EN

This article describes the design of photo catalyst reactor for oil removing from produced water. Real produced water containing a combination of organic compounds was treated with zinc oxide nanoparticles. In this study, ultraviolet radiations were used to find the efficiency of removing the oil content from the water produced that brought from the Al-Ahdab oilfield in kut/ Iraq by advanced oxidation process (AOP) using (ZnO/UV) in batch system and continuous system. In batch system were studied the effect of zinc oxide concentration (nanoparticles), time of irradiation, and pH. The highest removal rate of oil from the produced water (100%) was obtained during the following optimal conditions: ZnO NPs as catalyst = 55 mg/L, pH =3, at the time of irradiation of 90 minutes in batch experiments. In the continuous system, the effects of flowrate, number of UV-A lamp and time of reaction were studied, the results obtained were the efficiency of decomposition decreases with increasing the flow rate of solution in reactor, the maximum removal efficiency of the process (ZnO/UV) was 80% at 20 mL/min and irradiation time 120 min. In general, zinc oxide is beneficial through its high oil adsorption capacity in addition, It lowers the amount of oil in the produced water.

Słowa kluczowe

EN

photocatalytic; produced water; oil content; advanced oxidation processes; AOPs; ZnO/UV

• Wydawca: Polskie Towarzystwo Inżynierii Ekologicznej ; Lublin University of Technology
• Czasopismo: Journal of Ecological Engineering
• Rocznik: 2021
• Tom: Vol. 22, nr 8
• Strony: 278--286
• Opis fizyczny: Bibliogr. 33 poz., rys., tab.

Twórcy

autor

Alkhazraji Hussein Ali Jabbar

• Department of Environmental Engineering, College of Engineering, Mustansiriyha University, P.O. Box 14150, Babal-Mu’adhem, Baghdad, Iraq

autor

Alatabe Mohammed Jaafar Ali

• Department of Environmental Engineering, College of Engineering, Mustansiriyha University, P.O. Box 14150, Babal-Mu’adhem, Baghdad, Iraq

• https://orcid.org/0000-0002-0919-3596

Bibliografia

• 1. Rodriguez A.Z., Wang H., Hu L., Zhang Y., Xu P. 2020. Treatment of produced water in the permian basin for hydraulic fracturing: Comparison of different coagulation processes and innovative filter media. Water, 12(3), 770.
• 2. Hu L., Yu J., Luo H., Wang H., Xu P., Zhang Y. 2020. Simultaneous recovery of ammonium, potassium and magnesium from produced water by struvite precipitation. Chem. Eng. J., 382, 123001.
• 3. Aziz A.R.A. & Daud W.M.A.W. 2012. Oxidative mineralisation of petroleum refinery effluent using Fentonlike process. Chem. Eng. Res. Des., 90(2), 298–307.
• 4. Jiménez S. et al. 2017. Integrated processes for produced water polishing: Enhanced flotation/sedimentation combined with advanced oxidation processes. Chemosphere, 168, 309–317.
• 5. Sapareng S., Ala A., Kuswinanti T., Rasyid B. 2018. The ability of trichoderma sp and pleurotus sp for the decomposition of oil palm empty bunches. Pak. J. Biotechnol, 15(2) 543–548.
• 6. Okiel K., El-Sayed M., El-Kady M.Y. 2011. Treatment of oil–water emulsions by adsorption onto activated carbon, bentonite and deposited carbon. Egypt. J. Pet., 20(2), 9–15.
• 7. Fathy M., El-Sayed M., Ramzi M., Abdelraheem O.H. 2018. Adsorption separation of condensate oil from produced water using ACTF prepared of oil palm leaves by batch and fixed bed techniques. Egypt. J. Pet. 27(3), 319–326.
• 8. Shokrollahzadeh S., Golmohammad F., Naseri N., Shokouhi H., Arman-Mehr M. 2012. Chemical oxidation for removal of hydrocarbons from gas–field produced water. Procedia Eng., 42, 942–947.
• 9. Alvarez-Corena J.R., Bergendahl J.A., Hart F.L. 2016.Advanced oxidation of five contaminants in water by UV/TiO2: reaction kinetics and byproducts identification. J. Environ. Manage., 181, 544–551.
• 10. Karimi L., Zohoori S., Yazdanshenas M.E. 2014. Photocatalytic degradation of azo dyes in aqueous solutions under UV irradiation using nano-strontium titanate as the nanophotocatalyst. J. Saudi Chem. Soc., 18(5), 581–588.
• 11. Hernández-Francisco E., Peral J., Blanco-Jerez L.M. 2017. Removal of phenolic compounds from oil refinery wastewater by electrocoagulation and Fenton/photo-Fenton processes. J. Water Process Eng., 19, 96–100.
• 12. Fouad Y.O. 2014. Separation of cottonseed oil from oil–water emulsions using electrocoagulation technique. Alexandria Eng. J., 53(1), 199–204.
• 13. Mousa K.M., Al-Hasan A.A. 2017. Oilfield produced water treatment by coagulation/flocculation processes. Proceedings of the Second Conference of Post Graduate Researches (CPGR’2017), College of Engineering.
• 14. El-Din G.A., Amer A.A., Malsh G., Hussein M. 2018. Study on the use of banana peels for oil spill removal. Alexandria Eng. J., 57(3), 2061–2068.
• 15. Li Q., Kang C., Zhang C. 2005. Waste water produced from an oilfield and continuous treatment with an oil-degrading bacterium. Process Biochem., 40(2), 873–877.
• 16. Coto M., Troughton S.C., Duan J., Kumar R.V., Clyne T.W. 2018. Development and assessment of photo-catalytic membranes for water purification using solar radiation. Appl. Surf. Sci., 433, 101–107.
• 17. Poyatos J.M., Muñio M.M., Almecija M.C., Torres J.C., Hontoria E., Osorio F., 2010. Advanced oxidation processes for wastewater treatment: state of the art. Water. Air. Soil Pollut., 205(1), 187–204.
• 18. Rueda-Márquez J.J., Sillanpää M., Pocostales P., Acevedo A., Manzano M.A. 2015. Post-treatment of biologically treated wastewater containing organic contaminants using a sequence of H2O2 based advanced oxidation processes: photolysis and catalytic wet oxidation. Water Res., 71, 85–96.
• 19. Tony M.A., Purcell P.J., Zhao Y.Q., Tayeb A.M., ElSherbiny M.F. 2009. Photo-catalytic degradation of an oil-water emulsion using the photo-fenton treatment process: Effects and statistical optimization. J. Environ. Sci. Heal. Part A, (44) 2, 179–187.
• 20. Czaplicka M. 2006. Photo-degradation of chlorophenols in the aqueous solution. J. Hazard. Mater., 134(1–3), 45–59.
• 21. Malato S., Fernández-Ibáñez P., Maldonado M.I., Blanco J., Gernjak W. 2009. Decontamination and disinfection of water by solar photocatalysis: recent overview and trends. Catal. today., 147(1), 1–59.
• 22. Rao A.N., Sivasankar B., Sadasivam V. 2009. Kinetic study on the photocatalytic degradation of salicylic acid using ZnO catalyst. J. Hazard. Mater., 166, (2–3), 1357–1361.
• 23. Ebrahiem E.E., Al-Maghrabi M.N., Mobarki A.R. 2017. Removal of organic pollutants from industrial wastewater by applying photo-Fenton oxidation technology. Arab. J. Chem., 10, 1674–1679.
• 24. Aljuboury D. al deen A., Palaniandy P., Aziz H.B.A., Feroz S. 2016. Withdrawn: Comparison and performance of petroleum wastewater treatment using photocatalytic TiO2, photo Fenton, TiO2/Fenton and TiO2/Fenton/ZnO processes. Water Resources and Industry.
• 25. Tiburtius E.R.L., Peralta-Zamora P., Emmel A. 2005. Treatment of gasoline-contaminated waters by advanced oxidation processes. J. Hazard. Mater., 126 (1–3), 86–90.
• 26. Chatzisymeon E., Foteinis S., Mantzavinos D., Tsoutsos T. 2013. Life cycle assessment of advanced oxidation processes for olive mill wastewater treatment. J. Clean. Prod., 54, 229–234.
• 27. Ling H., Kim K., Liu Z., Shi J., Zhu X., Huang J. 2015. Photocatalytic degradation of phenol in water on as-prepared and surface modified TiO2 nanoparticles. Catal. Today., 258, 96–102.
• 28. Hassan A.A. & Al-zobai K.M.M. 2019. Chemical oxidation for oil separation from oilfield produced water under UV irradiation using Titanium dioxide as a nano-photocatalyst by batch and continuous techniques. Int. J. Chem. Eng., vol. 2019.
• 29. Faisal M., Khan S.B., Rahman M.M., Jamal A., Abdullah M.M. 2012. Fabrication of ZnO nanoparticles based sensitive methanol sensor and efficient photocatalyst. Appl. Surf. Sci., 258(19), 7515–7522.
• 30. Hassan A.A., Naeem H., Hadi R. 2018. Degradation of oily waste water in aqueous phase using solar (ZnO, TiO2 and Al2O3) catalysts. Pakistan J. Biotechnol., 15, 909–916.
• 31. Mitrović J., Radović M., Bojić D., Anđelković T., Purenović M., Bojić A. 2012. Decolorization of textile azo dye reactive orange 16 with UV/H2O2 process. J. Serbian Chem. Soc., 77(4), 465–481.
• 32. Mohammed R.M. Al-zobai K.M.M. 2020. Photocatalytic degradation of organic pollutants in petroleum refinery using TiO2/UV and ZnO/UV by batch and continuous process. Solid State Technol., 63(3), 5390–5404.
• 33. Monteiro R.A.R., Rodrigues-Silva C., Lopes F.V.S., Silva A.M.T., Boaventura R.A.R., Vilar V.J.P. 2015. Evaluation of a solar/UV annular pilot scale reactor for 24 h continuous photocatalytic oxidation of ndecane. Chem. Eng. J., 280, 409–416.