Synthesis of vanadium-enriched oxide materials via modified sol-gel route with the use of waste solutions contaminated with vanadium ions

• Autorzy: Weidner Ewelina , Piasecki Adam , Siwińska-Ciesielczyk Katarzyna , Jesionowski Teofil , Ciesielczyk Filip

Identyfikatory

DOI

10.37190/ppmp/126683

• Języki publikacji: EN

Abstrakty

EN

In this study, the synthesis of zirconia as well as zirconia enriched with vanadium by modified sol-gel method was presented. The modification of the method was based on the replacement of the traditional basic promoter of hydrolysis, which is ammonia, with sodium hydroxide solution. The most favorable conditions for the synthesis of zirconium with a new hydrolysis promoter were selected. A comparative analysis of ZrO₂ obtained using various hydrolysis promoters was performed. Both materials exhibited almost the same physicochemical properties, which proves that in this case the nature of the hydrolysis promoter used in sol-gel route does not significantly affect the properties of the ZrO₂. Then, synthesis of ZrO₂/V systems was carried out using model and real solutions containing vanadium ions as hydrolysis promoters. The solutions formed after vanadium catalyst leaching were used as real solutions. The effect of vanadium concentration and the presence of impurities on the final physicochemical properties of the obtained hybrid materials were investigated via scanning electron microscopy (SEM), dynamic light scattering (DLS), energy-dispersive X-ray microanalysis (EDS), Fourier transform infrared spectroscopy (FT-IR), low-temperature nitrogen sorption (BET), thermogravimetric analysis (TGA). The analysis of the obtained results allows to state that the developed technique for the synthesis of ZrO₂ and ZrO₂/V systems, using a modified sol-gel method, enabled the production of attractive materials.

Słowa kluczowe

EN

modified sol-gel method; zirconia; vanadium recovery; hybrid oxide materials; harmful metal ions

• Wydawca: Oficyna Wydawnicza Politechniki Wrocławskiej
• Czasopismo: Physicochemical Problems of Mineral Processing
• Rocznik: 2020
• Tom: Vol. 56, iss. 6
• Strony: 60--75
• Opis fizyczny: Bibliogr. 29 poz., rys., tab., wykr., wz.

Twórcy

autor

Weidner Ewelina

• Poznan University of Technology, Faculty of Chemical Technology, Institute of Chemical Technology and Engineering, Berdychowo 4, PL-60965 Poznan, Poland

autor

Piasecki Adam

• Poznan University of Technology, Faculty of Materials Engineering and Technical Physics, Institute of Materials Science and Engineering, Jana Pawla II 24, PL-60965 Poznan, Poland

autor

Siwińska-Ciesielczyk Katarzyna

• Poznan University of Technology, Faculty of Chemical Technology, Institute of Chemical Technology and Engineering, Berdychowo 4, PL-60965 Poznan, Poland

autor

Jesionowski Teofil

• Poznan University of Technology, Faculty of Chemical Technology, Institute of Chemical Technology and Engineering, Berdychowo 4, PL-60965 Poznan, Poland

autor

Ciesielczyk Filip

• Poznan University of Technology, Faculty of Chemical Technology, Institute of Chemical Technology and Engineering, Berdychowo 4, PL-60965 Poznan, Poland

Bibliografia

• ALBRECHT, S., WENDT, G., LIPPOLD, G., ADAMSKI, A., DYREK, K., 1997. Characterization of modified V2O5-ZrO2 catalysts for the oxidative dehydrogenation of propane. Solid State Ion. 101-103, 909-914.
• ASSEM, F., OSKARSSON, A., 2015. Vanadium. Handbook on the Toxicology of Metals: Fourth Edition, Elsevier, 1347-1367.
• BASHIR, M., ASHRAF, R, IMTIAZ, M. RIAZ, S., NASEEM, S., 2013. Synthesis and Characterization of ZrO2-ZnO nanoparticles, The 2013 World Congress on Advances in nano, biomechanics, robotics and energy research (ANBRE13), Seul, Korea.
• CHEN, X., LONG, C., Lin, C., WEI, T, YAN, J, 2014. Al and Co co-doped α-Ni(OH)2/graphene hybrid materials with high electrochemical performances for supercapacitors. Electrochim. Acta 137, 352-358.
• COATES, J., 2006. Interpretation of infrared spectra, a practical approach, Encyclopedia of Analytical Chemistry, John Wiley & Sons Ltd, 1-23.
• JAAFARZADEH, N., 2018. Removal of vanadium and palladium ions by adsorption onto magnetic chitosan nanoparticles. Environ. Sci. Pollut. Res. 25, 34262-34276.
• KRUK, M., JARONIEC, M., 2001, Gas adsorption characterization of ordered organic - inorganic nanocomposite materials. Chem. Mater. 13, 3169-3183.
• KURC, B., SIWIŃSKA-STEFAŃSKA, K., JESIONOWSKI, T., 2017. Bismuth-titanium-silicon-based ternary oxide system: A comprehensive analysis and electrochemical utility. Solid State Ion. 324, 92-102.
• KVISLE, S., AGUERO, A., SNEEDEN, R., 1988. Transformation of ethanol into 1,3-butadiene over magnesium oxide/silica catalysts. Appl. Cat. 43(1), 117-131.
• LE TOULLEC, M., SIMMONS, C., SIMMONS, J., 1988. Infrared spectroscopic studies of the hydrolysis reaction during leaching of heavy-metal fluoride glasses, J. Am. Ceram. Soc. 71, 219-224.
• LIU, H., SUN, X., YIN, C. HU, C., 1008. Removal of phosphate by mesoporous ZrO2, J. Hazard. Mater. 151, 616-622.
• MADHUSUDHANA, H.C., SHOBHDEVIC, S., NAGABHUSHANA, B., CHALUVARAJU, B., MURUGENDRAPPA, M., HARI KRISHNA, R., NAGAHUSHANA, H., RADEEP, N., 2006. Effect of fuels on conductivity, dielectric and humidity sensing properties of ZrO2 nanocrystals prepared by low temperature solution combustion method. J. Asian Ceram. Soc. 4, 309-318.
• MAROUKA, D., NANKO, M., 2013. Recovery of mechanical strength by surface crack disappearance via thermal oxidation for nano-Ni/Al2O3 hybrid materials. Ceram Int. 39(3), 3221-3229.
• NAGUIB, H., KELLY, R., 1970, The crystallization of amorphous ZrO2 by thermal heating and by ion bombardment, J. Nucl. 35(3), 293-305.
• PADMAMLINI, N., AMBUJAM, K., 2014. Optical and dielectric properties of ZrO2-V2O5 nanocomposites by co- precipitation calcination method. Superlattice. Microst. 76, 376-384.
• PATEL, S., BAKER, N., MAQUES, I., HAMLEKHAN, A., MATHEW, M., TAKOUDIS, C., FRIEDRICH, C., SUKOTJO, Co., SHOKUHFAR, T., 2017, Transparent TiO2 nanotubes on zirconia for biomedical applications, RCS Adv. 7, 30397
• PINHO, L., ELHADDAD, F., FACIO, D., MOSQUERA, M., 2013. A novel TiO2–SiO2 nanocomposite converts a very friable stone into a self-cleaning building material. Appl. Surf. Sci. 275, 389-396.
• RASHEED, P., HAQ, S., WASEEM, M., REHMAN, S., REHMAN, W., BIBI, N., SHAH, S., 2020. Green synthesis of vanadium oxide-zirconium oxide nanocomposite for the degradation of methyl orange and picloram. Mater. Res. Express 7, 025011.
• SAKKA, S., 2013, Sol-Gel Process and Applications, Handbook of Advanced Ceramics (Second Edition). Elsevier. 883-910.
• SARKAR, D, MOHAPATRA, D., RAY, S., BHATTACHARYYA, S., ADAK, S., MITRA, N., 2007. Synthesis and characterization of sol–gel derived ZrO2 doped Al2O3 nanopowder, Ceram. Int. 33, 1275-1282.
• SHARIFIFARD, H., SOLEIMANI, M., ZOKAEE ASHTIANI, F., 2016. Application of nanoscale iron oxide-hydroxide- impregnated activated carbon (Fe-AC) as an adsorbent for vanadium recovery from aqueous solutions. Desalin. Water Treat. 57, 15714-15723.
• SIMMONS, C., 1992. Corrosion of heavy-metal fluoride glasses. Ceramics and ceramic superconductors: principles, testing, characterization and applications, Noyes Publications, Park Ride, USA.
• SING, S.W., EVERETT, D.H., HAUL, R.A.W., MOSCOU, L., PIEROTTI, R.A., ROUQUEROL, J, SIEMIENIEWSKA, T., 1985. Reporting physisorption data for gas/solid systems — with special reference to the determination of surface area and porosity. Pure & Appl. Chem. 57(4), 603-619.
• SIWIŃSKA-STEFAŃSKA, K., KURC, B., 2017. A composite TiO2-SiO2-ZrO2 oxide system as a high-performance anode material for lithium-ion batteries. J. Electrochem. Soc. 164(4), 728-734.
• SONG, L., JIANG, Q., DU, P., YANG, Y., XIONG, J., CUI, C., 2014. Novel structure of TiO2–ZnO core shell rice grain for photoanode of dye-sensitized solar cells. J. Power Sources 261, 1-6.
• SU, J., LI, Y., WANG, H., 2016. Super-microporous solid base MgO-ZrO2 composite and their application in biodiesel production. Chem. Phys. Lett. 663, 61-66.
• SUN. T., ZHAO, Z., LIANG, Z., LIU, J., SHI, W., CUI, F., 2017. Efficient removal of arsenite through photocatalytic oxidation and adsorption by ZrO2-Fe3O4 magnetic nanoparticles. Appl. Surf. Sci. 416, 656-66.
• TYAGI, B., SIDHIPURIA, K., SHAIK, B., JASRA, R., 2006. Synthesis of nanocrystalline zirconia using sol-gel and precipitation techniques. Ind. Eng. Chem. Res. 45(25), 8643-8650.
• WANG, G., FENG, W., ZENG, X., FENG, C., DELECTIC, A., 2016. Highly recoverable TiO2–GO nanocomposites for stormwater disinfection. Water Res. 94, 363-370.

Uwagi

This work was supported by the National Science Centre Poland under research project no.2018/29/B/ST8/01122.