Wpływ sepiolitu na właściwości autoklawizowanego betonu komórkowego

• Autorzy: Demir İ. , Savaş M. , Yaprak H. , Doğan O. , Özel G.

Warianty tytułu

EN

Investigation of effect of sepiolite on the properties of autoclaved aerated concrete

• Języki publikacji: PL EN

Abstrakty

PL

W pracy zbadano wpływ dodatku sepiolitu, zastępującego piasek kwarcowy w autoklawizowanym betonie komórkowym (ABK) na właściwości tego kompozytu cementowego. Doświadczenia wykazały, że dodatek sepiolitu większy od 10% zmniejsza wytrzymałość na ściskanie ABK i zwiększa zawartość wilgoci, już przy dodatku 5%. Także gęstość suchych próbek ulega szybkiemu zmniejszeniu przy wzroście tego dodatku do 15%, a od 20% do 25% już wolniej. Natomiast przewodność cieplna zmniejsza się znacznie z poziomu 0,105 do 0,088 już w przypadku dodatku sepiolitu, wynoszącej 10%. Ten poziom dodatku sepiolitu, zastępującego piasek kwarcowy, można uznać za najlepszy.

EN

In the work the effect of sepiolite addition, replacing quartz sand in the autoclaved cellular concrete (ACC), on the properties of this cement composite was examined. It was found that sepiolite content higher than 10% is decreasing compressive strength of ACC and increasing its moisture content, already at addition of 5%. Also dry density is decreasing quickly up to 15% and from 20% to 25% only slowly. However, thermal conductivity is decreasing substantially from 0.105 to 0.088 for 10% sepiolite addition. 10% of sepiolite is the best level of replacement of quartz sand in ACC.

Słowa kluczowe

PL

beton komórkowy; ABK; dodatek do betonu; sepiolit; badanie doświadczalne; właściwości betonu

EN

cellular concrete; AAC; concrete additive; sepiolite; experimental investigation; concrete characteristics

• Wydawca: Fundacja Cement, Wapno, Beton
• Czasopismo: Cement Wapno Beton
• Rocznik: 2015
• Tom: R. 20/82, nr 6
• Strony: 359--365
• Opis fizyczny: Bibliogr. 18 poz., il., tab.

Twórcy

autor

Demir İ.

• Department of Civil Engineering, Kırıkkale University, Kırıkkale, Turkey

autor

Savaş M.

• General Directorate of State Hydraulic Works, Civil Engineer, Kırşehir, Turkey

autor

Yaprak H.

• Department of Civil Engineering, Kastamonu University, Kastamonu, Turkey

autor

Doğan O.

• Department of Civil Engineering, Kırıkkale University, Kırıkkale, Turkey

autor

Özel G.

• Türk Telekom, Ankara, Turkey

Bibliografia

• 1. M. Albayrak, A. Yörükoğlu, S . Karahan, S. Atlıhan, H. Y. Aruntaş, I. Girgin, Influence of zeolite additive on properties of autoclaved aerated concrete, Building and Environment, 42, 3161–3165 (2007).
• 2. DPT Dokuncu Kalkınma Planı (2007-201 3): Madencilik Özelİhtisas Komisyonu Raporu. Başbakanlık Devlet Planlama Teşkilatı, Ankara 2007 (in Turkish).
• 3. E. Fuente, R. Jarabo, A. Moral, C. Negro, L. Izquiredo, Effect of sepiolite on retention and drainage of suspensions of fiber–reinforced cement. Constr. Build. Mat., 24, 2117-2123 (2010).
• 4. K. Güçlüer, Uçucu külden üretilen silis dumanı katkılı gazbeton örnekleri üzerine kür etkisinin araştırılması, Yüksek Lisans Tezi, Afyon Kocatepe Üniversitesi, Afyon 2011 (in Turkish).
• 5. A. Hauser, U. Eggenberger, T. Mumenthaler, Fly ash from cellulose industry as secondary raw material in autoclaved aerated concrete, Cem. Concr. Res., 29, 297-302 (1999).
• 6. X. Huang, W. Ni, W. Cui, Z. Wang, L. Zhu, Preparation of autoclaved aerated concrete using copper tailings and blast, Constr. Build. Mat., 27, 1-5 (2012).
• 7. R. Jarabo, E. Fuente, A. Moral, Á. Blanco, L. Izquiredo, C. Negro, Effect of sepiolite on the flocculation of suspensions of fibre-reinforced cement, Cem. Concr. Res., 40, 1524-153 (2010).
• 8. İ. Kara, Seyitömer Uçucu külünün farklı yapı malzemeleri olarak değerlendirilmesi. Institute of Science and Technology, PhD Thesis, Eskişehir, Turkey 2008 (in Turkish).
• 9. T. Kavas, E. Sabah, M. S. Çelik, Structual Properties of Sepiolite-Reinforced Cemenet Composite, Cem. Concr. Res., 34, 2135-2139 (2004).
• 10. Ş. Kozak, Gazbeton üretiminde uçucu külün hammadde olarak kullanımının araştırılması, Institute of Science and Technology, PhD Thesis, Afyon, Turkey 2010.
• 11. E. K. Kunhanandan Nambiar, K. Ramamurthy, Influence of filler type on the properties of foam concrete, Cem. Concr. Comp., 28, 5, 475-480 (2006).
• 12. N. Y. Mostafa, Influence of air-cooled slag on physicochemical properties of autoclaved aerated concrete, Cem. Concr. Res., 35, 1349-1357 (2005).
• 13. TS EN 678; Determination of the dry density of autoclaved aerated concrete. Turkish Standards Institute, Ankara, Turkey 1995.
• 14. TS EN 679; Determination of the compressive strength of autoclaved aerated concrete. Turkish Standards Institute, Ankara, Turkey 2008.
• 15. TS EN 771-4; Specification for masonry units - Part 4: Autoclaved aerated concrete masonry units. Turkish Standards Institute, Ankara, Turkey 2012.
• 16. TS EN 772-10; Methods of test for masonry units - Part 10: Determination of moisture content of calcium silicate and autoclaved aerated concrete units. Turkish Standards Institute, Ankara, Turkey 2000.
• 17. TS ISO 8301; Thermal insulation - Determination of steady - state thermal resistance and related properties - Heat flow meter apparatus. Turkish Standards Institute, Ankara, Turkey 2002.
• 18. Y. Yılmaz, Eskişehir Yöresi Sepiyolitinin, Termal Özelliklerinin İncelenmesi, Yüksek Lisans Tezi, Anadolu Üniversitesi, Eskişehir 2007 (in Turkish).