Synthesis of kaolin-based zeolite Y and its application for adsorption of two carbonyl compound gases

• Autorzy: Warzybok M. , Warchoł J.

Identyfikatory

DOI

10.7862/rb.2018.2

• Języki publikacji: EN

Abstrakty

EN

The aim of the study was to synthesize zeolite Y based on natural clay mineral and to determine its potential for adsorption of carbonyl compounds. The synthesis route consisted of four steps: thermal activation of kaolin into metakaolin; aging of reaction mixtures at ambient temperature; crystallization of the reaction mixture; washing and drying of the final product. The reaction mixture consisted of metakaolin silica gel (SiO2), sodium chloride (NaCl) and sodium hydroxide (NaOH). All substrates were used at an intended molar ratio. The physicochemical properties of the synthesized adsorbent were attained through the advanced instrumental analysis. The adsorption of acetone and methyl ethyl ketone (MEK) on synthesized zeolite as well as on four commercially available adsorbents and three natural materials was examined in a dedicated home-made installation. The results showed, that the synthesized zeolite Y has the highest affinity for acetone over other adsorbents, while its affinity for MEK is only a little lower then AC. Additionally, adsorption isotherms of acetone and MEK on zeolite Y were measured on a gravimetric balance. Experimental binding isotherms were fitted by a non-linear regression to five empirical equations. In both acetone and MEK cases, the best results of statistical tests were obtained for the Marczewski-Jaroniec model.

Słowa kluczowe

EN

adsorption; acetone; methyl ethyl ketone; Y zeolites

• Wydawca: Oficyna Wydawnicza Politechniki Rzeszowskiej
• Czasopismo: Czasopismo Inżynierii Lądowej, Środowiska i Architektury / Journal of Civil Engineering, Environment and Architecture
• Rocznik: 2018
• Tom: z. 65, nr 1
• Strony: 13--26
• Opis fizyczny: Bibliogr. 42 poz., rys., tab.

Twórcy

autor

Warzybok M.

• Rzeszów University of Technology, Department of Water Purification and Protection, al. Powstańców Warszawy 6, 35-959 Rzeszów, Poland or Otto Engineering Polska Sp. z o. o., ul. Połonińska 15, 35-082 Rzeszów, Poland, 726-104-604

autor

Warchoł J.

• Wrocław University of Science and Technology, Department of Chemical Technologies and Processes, Wybrzeże Wyspiańskiego 42, 50-370 Wrocław, Poland, 713203839

Bibliografia

• [1] Adeoye J. B., Omoleye J. A., Ojewumi M. E., Babalola R.: Synthesis of Zeolite Y from Kaolin Using Novel Method of Dealumination, International Journal of Applied Engineering Research, 5/12, 2017, 755-760.
• [2] Ahmedzeki N.S., Yilmaz S., Al-Tabbakh B.A.: Synthesis and Characterization of Nanocrystalline Zeolite Y, Al-Khwarizmi Engineering Journal, 1/12, 2016, 79-89.
• [3] Alaba P.A., Sani Y.M., Daud W.M.A.W.: Synthesis and characterization of hierarchical nanoporous HY zeolites from acid-activated kaolin, Chinese Journal of Catalysis, 36, 2015, 1846-1851.
• [4] Ayele L., Perez-Pariente J., Chebude Y., Diaz I.: Synthesis of zeolite A from Etiopian kaolin, Microporous and Mesoporous Materials, 215, 2015, 29-36.
• [5] Bortolatto L.B., Boca Santa R.A.A., Moreira J.C., Machado D.B., Martins M.A.P.M., Fiori M.A., Kuhnen N.C., Riella H.G.: Synthesis and characterization of Y zeolites from alternative silicon and aluminium sources, Microporous and Mesoporous Materials, 248, 2017, 214-221.
• [6] Bradberry S.: Acetone, Medicine, 3/44, 2016, 127.
• [7] Chandrasekhar S., Pramada P.N.: Kaolin-based zeolite Y, a precursor for cordierite ceramics, Applied Clay Science, 27, 2004, 187-198.
• [8] Chang F.T., Lin Y.C., Bai H.L., Pei B.S.: Adsorption and desorption characteristic of semiconductor volatile organic compounds on the thermal swing honeycomb zeolite concentrator, Journal of Air & Waste Management Association, 53, 2003, 1384-1390.
• [9] Dobre T., Parvulescu O.C., Iavorschi G., Stroescu M., Stoica A.: EXPERIMENTAL STUDY OF VOCs ADSORPTION ONTO FIXED BED ACTIVATED CARBON, Analele UniversităŃii din Oradea Fascicula: Ecotoxicologie, Zootehnie si Tehnologii de Industrie Alimentară, 2010, 1241-1246.
• [10] Falth L., Hakansson U., Hansen S.: Structure of synthetic zeolite Na-P2, Acta Crystallographica Section C: Crystal Structure Communications, 46, 1990, 1361-1362.
• [11] Gangil S., Mewar Ch., Jha R., Kumar J., Malviya L., Modhera B.: Performance of 13X Zeolite for Volatile Organic Compound Adsorption by Pressure Swing Adsorption, Int. Conf. on Advances in Chemical Engineering and Technology, ICACE TKMCE, 2014, 41-44.
• [12] Garcia G., Cardenas E., Cabrera S., Hedlund J., Mouzon J.: Synthesis of zeolite Y from diatomite as silica source, Microporous and Mesoporous Materials, 219, 2016, 29-37.
• [13] Hellen H., Hakola H., Reissell A., Ruuskanen T.M.: Corbonyl compounds in boreal coniferous forest air in Hyytiala, Southern Finland, Atmospheric Chemistry and Physics, 4, 2004, 1771-1780.
• [14] Hilal G.: Liquid Phase Hydrogenation of Citral on Zeolite Supported Monometallic (Ni,Pt) and Bimetallic (Ni, Sn), (Pt-Sn) Catalysts, MSc Thesis, Izmir Institute of Technology, 2005.
• [15] Hildebrando E.A., Bastos Andrade Ch.G., Ferreira da Rocha Junior C.A., Angélica R.S., Valenzuela-Diaz F.R., de Freitas Neves R.: Synthesis and Characterization of Zeolite NaP Using Kaolin Waste as a Source of Silicon and Aluminum, Materials Research, 17(1), 2014, 174-179.
• [16] Htay M.M., Oo M.M.: Preparation of Zeolite Y Catalyst for Petroleum Cracking. World Aademy of Science, Engineering and Technology, 48, 2008, 114-120.
• [17] Huang W.L., Liu B.J., Sun F.M., Zhang Z.H., Bao X.J.: Synthesis and characterization of thermally stable MCM-41/γ-Al2O3 composite materials, Microporous and Mesoporous Materials, 94, 2006, 254.
• [18] Jha B., Singh D.N.: Fly Ash Zeolites, Advanced Structured Materials, 78, 2015, 5-31.
• [19] Jiang Ch., Li S., Zhang P., Wang J.: Pollution level and seasonal variations of carbonyl compounds, aromatic hydrocarbons and TVOC in a furniture mall in Beijing, China, Building and Environment, 69, 2013, 227-232.
• [20] Kazemimoghadam M., Mohammadi T.: Preparation of nano pore hydroxysodalite zeolite membranes using of kaolin clay and chemical sources, Desalination, 278, 2011, 438-442.
• [21] Khan F.I., Ghoshal A.Kr.: Removal of Volatile Organic Compounds from polluted air, Journal of Loss Prevention in the Process Industries, 13, 2000, 527-545.
• [22] Kulprathipanja S., Flanigen E.M., Broach R.W., Wilson S.T.: Zeolites in Industrial Separation and Catalysis, Chapter 1. Introduction. Wiley-VCH Verlag GmbH & Co. KGaA, 2010, 1-26.
• [23] Mark J.E.: Physical Properties of Polymers Handbook: Edition, Springer Science & Business Media, Berlin, 2007, 296-298.
• [24] Meng Q., Liu B., Piao J., Liu Q.: Synthesis of the composite material Y/ASA and its catalytic performance for the cracking of n-decane. Journal of Catalysis, 290, 2012, 55-64.
• [25] Omoleye J. A., Hymore F.K., Babalola R., Adefila S. S., Ajayi O.A.: Comparative Analysis of Zeolite Y From Nigerian Clay and Standard Grade. International Conference on African Development Issues (CU-ICADI) 2015: Materials Technology Track, 2015, 179-182.
• [26] Penkaj S., Su-Jung J., Moon-Hee H., Churl-Hee Ch.: Influence of the silica precursors on octahedron shaped nano NaY zeolite crystal synthesis, Journal of the Taiwan Institute of Chemical Engineers, 000, 2015, 1-7.
• [27] Pliś I., Prokop W., Petrus R., Warchoł J.: Sorption of acetone onto clay materials, 12 Scientific Conference POL-EMIS, Karpacz 4-7 June 2014.
• [28] Qi J., Li J., Li Y., Fang X., Sun X., Shen J., Han W., Wang L.: Synthesis of porous carbon beds with controllable pore structure for volatile organic compounds removal, Chemical Engineering Journal, 307, 2017, 989-998.
• [29] Qiu W., Dou K., Zhou Y., Huang H., Chen Y., Lu H.: Accepted Manuscript. Hierarchical pore structure of activated carbon fabricated by CO2/microwave for VOCs adsorption, Chinese Journal of Chemical Engineering, 2017.
• [30] San Cristobal A.G., Castello R., Martin Luengo M.A., Vizcayno C.: Zeolites prepared from calcined and mechanically modified kaolins. A comparative study, Applied Clay Science, 49, 2010, 239-246.
• [31] Sang S., Liu Z., Tian P., Liu Z., Qu L., Zhang Y.: Synthesis of small crystals zeolite NaY, Material Letters, 60, 2006, 1131-1133.
• [32] Sing K.S.W., Everett D.H., Haul R.A.W., Moscou L., Pierotti R.A., Rouquerol J., Siemieniewska T.: Reporting Physisorption Data for Gas/Solid Systems with Special Reference to the Determination of Surface Area and Porosit, Pure and Applied Chemistry, Vol. 57, No. 4, 1985, 603-619.
• [33] Tan Q.F., Bao X.J., Song T.C., Fan Y., Shi G., Shen B.J., Liu C.H., Gao X.H.: Synthesis, characterization, and catalytic properties of hydrothermally stable macromeso-micro-porous composite materials synthesized via in situ assembly of preformed zeolite Y nanoclusters on kaolin, Journal of Catalysis, 251, 2007, 69.
• [34] Tang L., Li L., Chen R., Wang Ch., Ma W., Ma X.: Adsorption of acetone and isopropanol on organic acid modified activated carbons, Journal of Environmental Chemical Engineering, 4, 2016, 2045-2051.
• [35] Tittarelli F., Giosue C., Mobili A., Ruello M.L.: Influence of binders and aggregates on VOCs adsorption and moisture buffering activity of mortars for indoor applications, Cement and Concrete Composites, 57, 2015, 75-83.
• [36] Ugal J.R., Hassan K.H., Ali I.H.: Preparation of type 4A zeolite from Iraqi kaolin: Characterization and properties measurements, Journal of the Association of Arab Universities for Basic and Applied Sciences, 9, 2010, 2-5.
• [37] United States Environmental Agency, Office of Air Quality, Technical bulletin, Zeolite a versatile air pollutant adsorber, 1998, http://www.epa.gov/ttn/catc.
• [38] Warzybok M., Chverenchuk A., Warchoł J.: Acetone adsorption on synthesized zeolite from natural clay material, Czasopismo Inżynierii Lądowej, Środowiska i Architektury – Journal of Civil Engineering, Environment and Architecture, JCEEA, z. 62, t. XXXII (3/I/15), 2015, 487-495, DOI:10.7862/rb.2015.132.
• [39] White D.H.: Compressed Air and Gas Purification and Fractionation for High Purity Applications by Improved PSA Processes, Separation Science and Technology, 43, 2008, 2298-2306.
• [40] Yuan W., Yuan P., Liu D., Deng L., Zhou J., Yu W., Chen F.: A hierarchically porous diatomite/silicalite-1 composite for benzene adsorption/desorption fabricated a facile pre-modification in situ synthesis route, Chemical Engineering Journal, 294, 2016, 333-342.
• [41] Zhang M., An T., Fu J., Sheng G., Wang X., Hu X., Ding X.: Photocatalytic degradation of mixed gaseous carbonyl compounds at low level on adsorptive TiO2/SiO2 photocatalyst using a fluidized bed reactor, Chemosphere, 64, 2006, 423-431.
• [42] Zhang P.: Adsorption and Desorption Isotherms, KE Group, 2016.

Uwagi

Opracowanie rekordu w ramach umowy 509/P-DUN/2018 ze środków MNiSW przeznaczonych na działalność upowszechniającą naukę (2019).