Microwave assistant synthesis of calcium phosphate minerals using hen’s eggshells as a calcium source

• Autorzy: Kalbarczyk Marta , Szcześ Aleksandra

Identyfikatory

DOI

10.37190/ppmp/127930

• Języki publikacji: EN

Abstrakty

EN

In this study raw hen’s eggshells were used as a calcium source for calcium phosphate mineral synthesis. The materials composed of brushite and different amounts of HA (hydroxyapatite) and β-TCP (β-tricalcium phosphate) with the needle-like, sheet-like and hexagonal structures were synthesized in the presence of the microwave. It was found that the time of microwave action, temperature and initial pH are parameters affecting the morphology and composition of the obtained materials, i.e. the increasing duration of MW exposure increases the amount of HA increases, whereas the temperature increase causes an increase in the contents of brushite and β-TCP. The lowering of initial pH leads to an increase in the brushite content.

Słowa kluczowe

EN

hydroxyapatite; brushite; β-TCP; microwave assisted synthesis

• Wydawca: Oficyna Wydawnicza Politechniki Wrocławskiej
• Czasopismo: Physicochemical Problems of Mineral Processing
• Rocznik: 2020
• Tom: Vol. 56, iss. 6
• Strony: 167--177
• Opis fizyczny: Bibliogr. 56 poz., rys., tab., wykr.

Twórcy

autor

Kalbarczyk Marta

• Department of Interfacial Phenomena, Institute of Chemical Sciences, Faculty of Chemistry, Maria Curie-Skłodowska University in Lublin, Sq. M. Curie-Skłodowska 3, 20-031 Lublin, Poland

autor

Szcześ Aleksandra

• Department of Interfacial Phenomena, Institute of Chemical Sciences, Faculty of Chemistry, Maria Curie-Skłodowska University in Lublin, Sq. M. Curie-Skłodowska 3, 20-031 Lublin, Poland

Bibliografia

• ACHAR, T.K., BOSE, A., MAL, P., 2017. Mechanochemical synthesis of small organic molecules. Beilstein J. Org. Chem. 13, 1907-1931.
• AKRAM, M., ALSHEMARY, A.Z., GOH, Y.-F., WAN IBRAHIM, W.A., LINTANG, H.O., HUSSAIN, R., 2015. Continuous microwave flow synthesis of mesoporous hydroxyapatite. Materials Science and Engineering: C 56, 356-362. https://doi.org/10.1016/j.msec.2015.06.040
• ALMUKARRAMAH, A., YUSUF, Y., 2020. Development Carbonated Hydroxyapatite Powders from Oyster Shells (Crassostrea gigas) by Carbonate Content Variations [WWW Document]. Materials Science Forum. https://doi.org/10.4028/www.scientific.net/MSF.975.76
• ANGERVALL, L., BERGER, S., ROCKERT, H., 1958. A Microradiographic and X-Ray Crystallographic Study of Calcium in the Pineal Body and in Intracranial Tumours. Acta Pathologica Microbiologica Scandinavica 44, 113-119.
• APALANGYA, V., RANGARI, V., JEELANI, S., DANKYI, E., YAYA, A., DARKO, S., 2018. Rapid microwave synthesis of needle-liked hydroxyapatite nanoparticles via template directing ball-milled spindle-shaped eggshell particles. Ceramics International 44, 7165-7171.
• BATISTA, H.A., SILVA, F.N., LISBOA, H.M., COSTA, A.C.F.M., 2020. Modeling and optimization of combustion synthesis for hydroxyapatite production. Ceramics International 46, 11638-11646.
• BEE, S.-L., HAMID, Z.A.A., 2019. Characterization of chicken bone waste-derived hydroxyapatite and its functionality on chitosan membrane for guided bone regeneration. Composites Part B: Engineering 163, 562-573.
• BINITHA, M.P., PRADYUMNAN, P.P., 2013. Dielectric Property Studies of Biologically Compatible Brushite Single Crystals Used as Bone Graft Substitute. J. Biomat. Nanobiotechnol. 04(02), 119-122.
• BRAMHE, S., KIM, T.N., BALAKRISHNAN, A., CHU, M.C., 2014. Conversion from biowaste Venerupis clam shells to hydroxyapatite nanowires. Materials Letters 135, 195-198.
• CHEN, J., LIU, J., DENG, H., YAO, S., WANG, Y., 2020. Regulatory synthesis and characterization of hydroxyapatite nanocrystals by a microwave-assisted hydrothermal method. Ceramics International 46, 2185-2193.
• CHESLEY, M., KENNARD, R., ROOZBAHANI, S., KIM, S.M., KUKK, K., MASON, M., 2020. One-step hydrothermal synthesis with in situ milling of biologically relevant hydroxyapatite. Materials Science and Engineering: C 113, 110962.
• CHOI, G., CHOI, A.H., EVANS, L.A., AKYOL, S., BEN-NISSAN, B., 2020. A review: Recent advances in sol-gel-derived hydroxyapatite nanocoatings for clinical applications. Journal of the American Ceramic Society, https://doi.org/10.1111/jace.17118
• CLARK-PERRY, D., LEVIN, L., 2020. Comparison of new formulas of stannous fluoride toothpastes with other commercially available fluoridated toothpastes: A systematic review and meta-analysis of randomised controlled trials. International Dental Journal n/a. https://doi.org/10.1111/idj.12588
• DARYAN, S.H., KHAVANDI, A., JAVADPOUR, J., 2020. Surface engineered hollow hydroxyapatite microspheres: Hydrothermal synthesis and growth mechanisms. Solid State Sciences 106, 106301.
• DE ANGELIS, G., MEDEGHINI, L., CPNTE, A.M., MIGNARDI, S., 2017. Recycling of eggshell waste into low-cost adsorbent for Ni removal from wastewater. Journal of Cleaner Production 164, 1497-1506.
• DERKUS, B., ARSLAN, Y.E., EMREGUL, K.C., EMREGUL, E., 2016. Enhancement of aptamer immobilization using egg shell-derived nano-sized spherical hydroxyapatite for thrombin detection in neuroclinic. Talanta 158, 100-109.
• EDRALIN, E.J.M., GARCIA, J.L., DELA ROSA, F.M., PUNZALAN, E.R., 2017. Sonochemical synthesis, characterization and photocatalytic properties of hydroxyapatite nano-rods derived from mussel shells. Materials Letters 196, 33-36.
• EPPLE, M., MEYER, F., ENAX, J., 2019. A Critical Review of Modern Concepts for Teeth Whitening. Dentistry Journal 7, 79.
• FEARON, J., 2007. Tooth whitening: concepts and controversies. J. Ir. Dent. Assoc. 53, 132-140.
• FEJERSKOV, O., KIDD, E., 2009. Dental Caries: The Disease and Its Clinical Management. John Wiley & Sons.
• GJORGIEVSKA, E.S., NICHOLSON, J.W., SLIPPER, I.J., STEVANOVIC, M.M., 2013. Remineralization of Demineralized Enamel by Toothpastes: A Scanning Electron Microscopy, Energy Dispersive X-Ray Analysis, and Three-Dimensional Stereo-Micrographic Study. Microscopy and Microanalysis 19, 587-595.
• GUO, X., YAN, H., ZHAO, S., LI, Z., LI, Y., LIANG, X., 2013. Effect of calcining temperature on particle size of hydroxyapatite synthesized by solid-state reaction at room temperature. Advanced Powder Technology 24, 1034-1038.
• GUTIERREZ-SALAZAR, M. del P., REYES-GASGA, J., 2003. Microhardness and chemical composition of human tooth. Materials Research 6, 367-373.
• HASSAN, M.N., MAHMOUD, M.M., EL-FATTAH, A.A., KANDIL, S., 2016. Microwave-assisted preparation of Nano-hydroxyapatite for bone substitutes. Ceramics International 42, 3725-3744.
• HASSAN, M.N., MAHMOUD, M.M., EL-FATTAH, A.A., KANDIL, S., 2015. Microwave rapid conversion of sol-gel-derived hydroxyapatite into β-tricalcium phosphate. J Sol-Gel Sci Technol 76, 74-81.
• HIRSCH, A., AZURI, I., ADDADI, L., WEINER, S., YANG, K., CURTAROLO, S., KRONIK, L., 2014. Infrared Absorption Spectrum of Brushite from First Principles. Chem. Mater. 26, 2934-2942.
• HUANG, H., DU, M., CHEN, J., ZHONG, S., WANG, J., 2020. Preparation and characterization of abalone shells derived biological mesoporous hydroxyapatite microspheres for drug delivery. Materials Science and Engineering: C 113,
• IBRAHIM, A.-R., ZHOU, Y., LI, X., CHEN, L., HONG, Y., SU, Y., WANG, H., LI, J., 2015. Synthesis of rod-like hydroxyapatite with high surface area and pore volume from eggshells for effective adsorption of aqueous Pb(II). Materials Research Bulletin 62, 132-141.
• ITTHAGARUN, A., KING, N., CHEUNG, Y.M., 2010. The effect of nano-hydroxyapatite toothpaste on artificial enamel carious lesion progression: An in-vitro pH-cycling study. Hong Kong Dental Journal 7, 61-66.
• JAYASREE, R., KUMAR, T.S.S., VENKATESWARI, R., NANKAR, R.P., DOBLE, M., 2019. Eggshell derived brushite bone cement with minimal inflammatory response and higher osteoconductive potential. J Mater Sci: Mater Med 30, 113.
• KUMAR, G.S., THAMIZHAVEL, A., GIRIJA, E.K., 2012. Microwave conversion of eggshells into flower-like hydroxyapatite nanostructure for biomedical applications. Materials Letters 76, 198-200.
• LEE, D., KUMTA, P.N., 2010. Chemical synthesis and stabilization of magnesium substituted brushite. Materials Science and Engineering: C 30, 934-943.
• LEGEROS, R.Z., LIN, S., ROHANIZADEH, R., MIJARES, D., LEGEROS, J.P., 2003. Biphasic calcium phosphate bioceramics: preparation, properties and applications. Journal of Materials Science: Materials in Medicine 14, 201-209.
• LIANG, T., QIAN, J., YUAN, Y., LIU, C., 2013. Synthesis of mesoporous hydroxyapatite nanoparticles using a template-free sonochemistry-assisted microwave method. J. Mater. Sci. 48, 5334-5341.
• LIU, C., HUANG, Y., SHEN, W., CUI, J., 2001. Kinetics of hydroxyapatite precipitation at pH 10 to 11. Biomaterials 22, 301-306.
• MALAU, N.D., ADINUGRAHA, F., 2020. Synthesis of hydrokxyapatite based duck egg shells using precipitation method. J. Phys.: Conf. Ser. 1563, 012020.
• NAKAHIRA, A., SAKAMOTO, K., YAMAGUCHI, S., KANENO, M., TAKEDA, S., OKAZAKI, M., 1999. Novel Synthesis Method of Hydroxyapatite Whiskers by Hydrolysis of alpha-Tricalcium Phosphate in Mixtures of Water and Organic Solvent. Journal of the American Ceramic Society 82, 2029-2032.
• NIAKAN, A., RAMESH, S., GANESAN, P., TAN, C.Y., PURBOLAKSONO, J., CHANDRAN, H., RAMESH, S., TENG, W.D., 2015. Sintering behaviour of natural porous hydroxyapatite derived from bovine bone. Ceramics International 41, 3024-3029.
• OFUDJE, E.A., RAJENDRAN, A., ADEOGUN, A.I., IDOWU, M.A., KAREEM, S.O., PATTANAYAK, D.K., 2018. Synthesis of organic derived hydroxyapatite scaffold from pig bone waste for tissue engineering applications. Advanced Powder Technology 29, 1-8.
• PARK, Y.M., RYU, S.C., YOON, S.Y., STEVENS, R., PARK, H.C., 2008. Preparation of whisker-shaped hydroxyapatite/β-tricalcium phosphate composite. Materials Chemistry and Physics 109, 440-447.
• PEPLA, E., BESHARAT, L.K., PALAIA, G., TENORE, G., MIGLIAU, G., 2014. Nano-hydroxyapatite and its applications in preventive, restorative and regenerative dentistry: a review of literature. Ann Stomatol (Roma) 5, 108-114.
• REHMAN, I., BONFIELD, W., 1997. Characterization of hydroxyapatite and carbonated apatite by photo acoustic FTIR spectroscopy. Journal of Materials Science: Materials in Medicine 8, 1-4. https://doi.org/10.1023/A:1018570213546
• RUSLAN, HARDI, J., KHAIRUDDIN, DEFLINDA, RISKAWATI, 2020. Synthesis of hydroxyapatite from meti shells (batissa violecea l. Von Lamark 1818) by wet precipitation method. J. Phys.: Conf. Ser. 1434, 012023.
• SODAT-SHOJAI, M., KHORASANI, M.-T., DINPANAH-KHOSHDARGI, E., JAMSHIDI, A., 2013. Synthesis methods for nanosized hydroxyapatite with diverse structures. Acta Biomaterialia 9, 7591-7621.
• SAJAHAN, N.A., WAN IBRAHIM, W.M.A., 2014. Microwave Irradiation of Nanohydroxyapatite from Chicken Eggshells and Duck Eggshells [WWW Document]. The Scientific World Journal. https://doi.org/10.1155/2014/275984
• SAMPATH KUMAR, T.S., MANJUBALA, I., GUNASEKARAN, J., 2000. Synthesis of carbonated calcium phosphate ceramics using microwave irradiation. Biomaterials 21, 1623-1629.
• SANCHEZ-ENRIQUEZ, J., REYES-GASGA, J., 2013. Obtaining Ca(H2PO4)2·H2O, monocalcium phosphate monohydrate, via monetite from brushite by using sonication. Ultrasonics Sonochemistry 20, 948-954.
• SHAVANDI, A., BEKHIT, A.E.-D.A., ALI, A., SUN, Z., 2015. Synthesis of nano-hydroxyapatite (nHA) from waste mussel shells using a rapid microwave method. Materials Chemistry and Physics 149-150, 607-616.
• SIKDER, P., REN, Y., BHADURI, S.B., 2020. Microwave processing of calcium phosphate and magnesium phosphate based orthopedic bioceramics: A state-of-the-art review. Acta Biomaterialia 111, 29-53.
• SINITSYNA, O.V., VERESOV, A.G., KOVALEVA, E.S., KOLEN’KO, Y.V., PUTLYAEV, V.I., TRETYAKOV, Y.D., 2005. Synthesis of hydroxyapatite by hydrolysis of α-Ca3(PO4)2. Russian Chemical Bulletin 1, 79-86.
• TANIMOTO, Y., HAYAKAWA, T., NEMOTO, K., 2005. Tape-casting technique can prepare β-TCP sheets with uniform thickness and flexibility. Journal of Biomedical Materials Research Part B: Applied Biomaterials 73B, 157-163.
• TSCHOPPE, P., ZANDIM, D.L., MARTUS, P., KIELBASSA, A.M., 2011. Enamel and dentine remineralization by nano-hydroxyapatite toothpastes. Journal of Dentistry 39, 430-437.
• WANG, Z., JIANG, T., SAURO, S., PASHLEY, D.H., TOLEDANO, M., OSORI, R., LIANG, S., XING, W., SA, Y., WANG, Y., 2011. The dentine remineralization activity of a desensitizing bioactive glass-containing toothpaste: an in vitro study. Australian Dental Journal 56, 372-381.
• YELTEN-YILMAZ, A., YILMAZ, S., 2018. Wet chemical precipitation synthesis of hydroxyapatite (HA) powders. Ceramics International 44, 9703-9710.
• YUDIN, A., ILINYKH, I., CHUPRUNOV, K., KOLESNIKOV, E., KUZNETSOV, D., LEYBO, D., GODYMCHUK, A., 2019. Microwave treatment and pH influence on hydroxyapatite morphology and structure. J. Phys.: Conf. Ser. 1145, 012003.
• ZHOU, H., YANG, M., ZHANG, M., HOU, S., KONG, S., YANG, L., DENG, L., 2016. Preparation of Chinese mystery snail shells derived hydroxyapatite with different morphology using condensed phosphate sources. Ceramics International 42, 16671-16676.