Evaluation of ecological extremes of vehicles in road emission tests

• Autorzy: Pielecha Jacek , Skobiej Kinga

Identyfikatory

DOI

10.5604/01.3001.0014.5516

• Języki publikacji: EN

Abstrakty

EN

New testing procedures for determining road emissions of exhaust pollutants for passenger vehicles were established in 2018. New road testing procedures are designed to determine actual exhaust emissions, which may not always reflect laboratory emissions. Test procedures for the emission of pollutants in real traffic conditions are divided into four stages. The latest research on the emission of pollutants from motor vehicles in road traffic conditions, carried out using mobile measuring systems, reflects the actual ecological state of vehicles. The article compares the results of exhaust emissions obtained in road tests using the latest legislative proposals for passenger cars. Then, an attempt was made to determine the engine operating parameters in which exhaust road emission would be the lowest. Solution scenarios were defined as part of permissible changes to dynamic parameters that are included in European legislation on RDE testing. For this purpose, an optimization tool was used, allowing on the basis of given input data to determine the minimum objective function, defined as the smallest emission value of individual harmful compounds. The results of the exhaust gas emissions in the RDE test were used to determine the road emissions of individual harmful compounds. A thorough analysis of the emission intensity of individual compounds has shown that it is possible to approximate such values using functional rela-tionships or adopting them as a constant value. This division was used to determine the extremes (in this case the minima) of the objective function (minimum road emissions of harmful exhaust components). This task resulted in obtaining (within the permissible tolerances of all driving parameters and durations of individual road test sections) the value of exhaust emissions in the range from 26% to 81% lower than in the actual road test. This means that there is a tolerance range, where you can obtain the value of emissions in road tests. As a result, you can use the process of determining the minimum emissions tests RDE calibration of the drive units already at the stage of preparation so that in the real traffic conditions characterized by the lowest exhaust emissions.

Słowa kluczowe

EN

exhaust emission; passenger cars; real driving emissions; optimization

PL

emisja spalin; samochody osobowe; badania emisji spalin; optymalizacja

• Wydawca: Warsaw University of Technology, Faculty of Transport
• Czasopismo: Archives of Transport
• Rocznik: 2020
• Tom: Vol. 56, iss. 4
• Strony: 33--46
• Opis fizyczny: Bibliogr. 33 poz., rys., tab., wykr.

Twórcy

autor

Pielecha Jacek

• Faculty of Civil and Transport Engineering, Poznan University of Technology, Poznan, Poland

autor

Skobiej Kinga

• Faculty of Civil and Transport Engineering, Poznan University of Technology, Poznan, Poland

Bibliografia

• [1] BIELACZYC, P., SZCZOTKA, A., WOODBURN, J., 2019. Carbon dioxide emissions and fuel consumption from passenger cars tested over the NEDC and WLTC – an overview and experimental results from market-representative vehicles. IOP Conf. Series: Earth and Environmental Science, 214, 012136. DOI: 10.1088/1755-1315/214/1/012136.
• [2] BUSCH, S., ZELLBECK, H., 2019. Particle emission of the direct-injection gasoline engine under real driving emissions conditions. MTZ worldwide, 80, 60-65. DOI: 10.1007/s38313-018-0122-5.
• [3] CHONG, H. S., PARK, Y., KWON, S., HONG, Y., 2018. Analysis of real driving gaseous emissions from light-duty diesel vehicles. Transportation Research Part D: Transport and Environment, 65, 485-499. DOI: 10.1016/j.trd.2018.09.015.
• [4] CLENCI, A., SĂLAN, V., NICULESCU, R., IORGA-SIMĂN, V., ZAHARIA, C., 2017. Assessment of real driving emissions via portable emission measurement system. IOP Conference Series: Materials Science and Engineering, 252, 012084, DOI: 10.1088/1757-899X/252/1/012084.
• [5] CR 715, 2007. Commission Regulation, 2007. No 715/2007 of the European Parliament and of the Council of 20 June 2007 on type approval of motor vehicles with respect to emissions from light passenger and commercial vehicles (Euro 5 and Euro 6) and on access to vehicle repair and maintenance information. Official J. European Union, L 171. http://data.europa.eu/eli/reg/2007/715/oj.
• [6] CR 692, 2008. Commission Regulation, 2008. No. 692/2008 of 18 July 2008 implementing and amending Regulation (EC) 715/2007 of the European Parliament and of the Council on type-approval of motor vehicles with respect to emissions from light passenger and commercial vehicles (Euro 5 and Euro 6) and on access to vehicle repair and maintenance information. European Commission (EC), Official J. European Union, L 199. http://data.europa.eu/eli/reg/2008/692/oj.
• [7] CR 427, 2016. Commission Regulation, 2016. No. 2016/427 of 10 March 2016 amending Regulation (EC) No. 692/2008 as regards emissions from light passenger and commercial vehicles (Euro 6), Verifying Real Driving Emissions. Official J. European Union, L 82. http://data.europa.eu/eli/reg/2016/427/oj.
• [8] CR 646, 2016. Commission Regulation, 2016. No. 2016/646 of 20 April 2016 amending Regulation (EC) No. 692/2008 as regards emissions from light passenger and commercial vehicles (Euro 6), Verifying Real Driving Emissions. Official J. European Union, L 109. http://data.europa.eu/eli/reg/2016/646/oj.
• [9] CR 1151, 2017. Commission Regulation, 2017. No. 2017/1151 of 1 June 2017 supplementing Regulation (EC) No 715/2007 of the European Parliament and of the Council on type-approval of motor vehicles with respect to emissions from light passenger and commercial vehicles (Euro 5 and Euro 6) and on access to vehicle repair and maintenance information, amending Directive 2007/46/EC of the European Parliament and of the Council, Commission Regulation (EC) No 692/2008 and Commission Regulation (EU) No 1230/2012 and re-pealing Commission Regulation (EC) No 692/2008. Official J. European Union, L 175. http://data.europa.eu/eli/reg/2017/1151/oj.
• [10] CR 1154, 2017. Commission Regulation, 2017. No. 2017/1154 of 7 June 2017 amending Regulation (EU) 2017/1151 supplementing Regulation (EC) No 715/2007 of the European Parliament and of the Council on type-approval of motor vehicles with respect to emissions from light passenger and commercial vehicles (Euro 5 and Euro 6) and on access to vehicle repair and maintenance information, amending Directive 2007/46/EC of the European Parliament and of the Council, Commission Regulation (EC) No 692/2008 and Commission Regulation (EU) No 1230/2012 and repealing Regulation (EC) No 692/2008 and Directive 2007/46/EC of the European Parliament and of the Council as regards real-driving emissions from light passenger and commercial vehicles (Euro 6). Official J. European Union, L 175. http://data.europa.eu/eli/reg/2017/1154/oj.
• [11] FONTARAS, G., FRANCO, V., DILARA, P., MARTINI, G., MANFREDI, U., 2014. Development and review of Euro 5 passenger car emission factors based on experimental results over various driving cycles. Science of The Total Environment, 468-469, 1034-1042. DOI: 10.1016/j.scitotenv.2013.09.043.
• [12] GAO, Y., CHECKEL, M. D., 2007. Emission factors analysis for multiple vehicles using an on-board, in-use emissions measurement system. SAE Technical Paper 2007-01-1327. DOI: 10.4271/2007-01-1327.
• [13] GIECHASKIEL, B., VLACHOS, T., RICCOBONO, F., FORNI, F., COLOMBO, R., MONTIGNY, F., LE-LIJOUR, P., CARRIERO, M., BONNEL, P., WEISS, M., 2016. Implementation of portable emissions measurement systems (PEMS) for the real-driving emissions (RDE) regulation in Europe. JoVE Video Journal, 118, e54753. DOI: 10.3791/54753.
• [14] GIS, M., 2019. Assessment of exhaust emissions from vehicles in real traffic conditions. IOP Conference Series: Earth and Environmental Science, 214, 012035. DOI: 10.1088/1755-1315/214/1/012035.
• [15] GIS, M., BEDNARSKI, M., 2019. Comparative studies of harmful exhaust emission from a hybrid vehicle and a vehicle powered by spark ignition engine. IOP Conference Series: Earth and Environmental Science, 421 (4), 042022. DOI: 10.1088/1757-899X/421/4/042022.
• [16] KAPUSTA, L. J., PIELECHA, I., WISLOCKI, K., TEODORCZYK, A., 2016. Autoignition and combustion of n-hexane spray in subcritical and supercritical environments. Journal of Thermal Analysis and Calorimetry, 123, 819-828. DOI: 10.1007/s10973-015-4927-z.
• [17] KORNISKI, T., GIERCZAK, C., WALLING-TON, T., 2007. Laboratory evaluation of the 2.5 inch diameter Semtech® exhaust flow meter with gasoline fueled vehicles. Sensors 4th Annual SUN Conference, Ann Arbor.
• [18] KOUSOULIDOU, M., FONTARAS, G., NTZIACHRISTOS, L.. BONNEL, P., SAMARAS, Z., DILARA, P., 2013. Use of portable emissions measurement system (PEMS) for the development and validation of passenger car emission factors. Atmospheric Environment, 64, 329-338. DOI: 10.1016/j.atmosenv.2012.09.062.
• [19] KÖHL, M. A., HERMANNS, H., BIEWER, S., 2018. Efficient monitoring of real driving emissions. In: COLOMBO, C., LEUCKER, M. (eds) Runtime Verification. Lecture Notes in Computer Science, 11237, Springer, Cham. DOI: 10.1007/978-3-030-03769-7_17.
• [20] LIM, J. H., HAN, S. W., KIM, J., JANG, Y. K., CHON, M. S., HWANG, S. C., KIM, J. H., JUNE, S. W., KIM, J. S., HAN, J. S., 2018. Emission factor of hazardous air pollutants in gas-phase from light commercial vehicle using PEMS on real-road driving. Journal of Korean Society for Atmospheric Environment, 34 (2), 191-206. DOI: 10.5572/KOSAE.2018.34.2.191.
• [21] MANSOUR, C., HADDAD, M., ZGHEIB, E., 2018. Assessing consumption, emissions and costs of electrified vehicles under real driving conditions in a developing country with an in-adequate road transport system. Transportation Research Part D: Transport and Environment, 63, 498-513. DOI: 10.1016/j.trd.2018.06.012.
• [22] MERKISZ, J., PIELECHA, J., 2018. Comparison of real driving emissions tests. IOP Confer-ence Series: Materials Science and Engineering, 421 (4), 042055. DOI: 10.1088/1757-899X/421/4/042055.
• [23] MERKISZ J., PIELECHA J., JASIŃSKI R., 2016. Remarks about real driving emissions tests for passenger cars. Archives of Transport, 39 (3), 51-63. DOI: 10.5604/08669546.1225449.
• [24] MERKISZ, J., PIELECHA, J., LIJEWSKI, P., MERKISZ-GURANOWSKA, A., NOWAK, M., 2013. Exhaust emissions from vehicles in real traffic conditions in the Poznan agglomeration. Air Pollution XXI Book Series: WIT Transactions on Ecology and the Environment, 174, 27-38. DOI: 10.2495/AIR130031.
• [25] MERKISZ, J., RYMANIAK, L., 2017. The assessment of vehicle exhaust emissions referred to CO2 based on the investigations of city buses under actual conditions of operation. Eksploatacja i niezawodność – Maintenance and reliability, 19(4), 522-529. DOI: 10.17531/ein.2017.4.5.
• [26] PIELECHA, I., 2014. Diagnostics of stratified charge combustion under the conditions of multiple gasoline direct injection. Journal of Thermal Analysis and Calorimetry, 118, 217-225. DOI: 10.1007/s10973-014-3956-3.
• [27] PIELECHA, J., ANDRYCH-ZALEWSKA, M., 2018. The influence of internal catalyst on exhaust emission in dynamic conditions. E3S Web of Conferences, 44, 00141. DOI: 10.1051/e3sconf/20184400141.
• [28] PIELECHA, J., MAGDZIAK, A., BRZEZINSKI, L., 2019. Nitrogen oxides emission evaluation for Euro 6 category vehicles equipped with combustion engines of different displacement volume. IOP Conference Series: Earth and Environmental Science, 214, 012010. DOI: 10.1088/1755-1315/214/1/012010.
• [29] STELMASIAK, Z., LARISCH, J., PIELECHA, J., PIETRAS, D., 2017. Particulate matter emission from dual fuel diesel engine fuelled with natural gas. Polish Maritime Research, 24 (2), 96-104. DOI: 10.1515/pomr-2017-0055.
• [30] SUN, B., ZHANG, T., GE, W., TAN, C., GAO, S., 2019. Driving energy management of front-and-rear-motor-drive electric vehicle based on hybrid radial basis function. Archives of Transport, 49 (1), 47-58. DOI: 10.5604/01.3001.0013.2775.
• [31] TRIANTAFYLLOPOULOS, G., KATSA-OUNIS, D., KARAMITROS, D., NTZIACHRISTOS, L., SAMARAS, Z., 2018. Experimental assessment of the potential to decrease diesel NOx emissions beyond minimum requirements for Euro 6 real drive emissions (RDE) compliance. Science of The Total Environment, 618, 1400-1407. DOI: 10.1016/j.sci-totenv.2017.09.274.
• [32] VARELLA, R. A., GIECHASKIEL, B., SOUSA, L., DUARTE, G., 2018. Comparison of portable emissions measurement systems (PEMS) with laboratory grade equipment. Applied Sciences, 8(9), 1633. DOI: 10.3390/app8091633.
• [33] WEISS, M., PAFFUMI, E., CLAIROTTE, M., DROSSINOS, Y., VLACHOS, T., BONNEL, P., GIECHASKIEL, B., 2017. Including cold-start emissions in the real-driving emissions (RDE) test procedure. Publications Office of the European Union. https://doi.org/10.2760/70237.