Performance evaluation of nanofiltration membranes for dye removal of synthetic hand-drawn batik industry wastewater

• Autorzy: Desiriani Ria , Susanto Heru , Aryanti Nita

Identyfikatory

DOI

10.37190/epe220104

• Języki publikacji: EN

Abstrakty

EN

This study evaluated the performance of nanofiltration (NF) membrane for the treatment of hand-drawn batik wastewater containing synthetic dyes as well as real batik wastewater. Three commercial NF membranes (NF270, TS40 and XN45) were used. The effect of transmembrane pressure, NF membrane types, synthetic dyes concentration, and solution types on flux and rejection were investigated. The results showed that the use of all NF membranes could reach dye removal of ca. 99%. NF270 membrane exhibited the highest flux, 2–3 times higher than that of TS40 and XN45 membranes. NF270 membrane was further used for treating real batik wastewater. The results showed high rejections in terms of total suspended solids (TSS), chemical oxygen demand (COD), and total dissolved solids (TDS) were obtained. The practical applicability of NF270 membrane for real handdrawn batik wastewater treatment fulfilled the quality standards in terms of TSS, COD, and BOD parameters. Overall, the NF270 membrane showed favorable performance for batik effluent treatment.

Słowa kluczowe

EN

COD; water filtration; nanofiltration; NF; batik industry

PL

ChZT; filtracja wody; nanofiltracja; NF; batik przemysłowy

• Wydawca: Oficyna Wydawnicza Politechniki Wrocławskiej
• Czasopismo: Environment Protection Engineering
• Rocznik: 2022
• Tom: Vol. 48, nr 1
• Strony: 51--68
• Opis fizyczny: Bibliogr. 25 poz., rys., tab.

Twórcy

autor

Desiriani Ria

• Membrane Research Center (MeR-C), Integrated Laboratory for Research and Services, Diponegoro University, Semarang, Indonesia
• Department of Chemical Engineering, Faculty of Engineering, Diponegoro University, Semarang, Indonesia

• https://orcid.org/0000-0001-6940-1767

autor

Susanto Heru

• Membrane Research Center (MeR-C), Integrated Laboratory for Research and Services, Diponegoro University, Semarang, Indonesia
• Department of Chemical Engineering, Faculty of Engineering, Diponegoro University, Semarang, Indonesia

• https://orcid.org/0000-0002-0258-7437

autor

Aryanti Nita

• Membrane Research Center (MeR-C), Integrated Laboratory for Research and Services, Diponegoro University, Semarang, Indonesia
• Department of Chemical Engineering, Faculty of Engineering, Diponegoro University, Semarang, Indonesia

• https://orcid.org/0000-0002-1999-4442

Bibliografia

• [1] MUKIMIN A., VISTANTY H., ZEN N., PURWABTO A., WICAKSONO K.A., Performance of bioequalization-electrocatalytic integrated method for pollutants removal of hand-drawn batik wastewater, J. Water Proc. Eng., 2018, 21, 77–83. DOI: 10.1016/j.jwpe.2017.12.004.
• [2] BIRGANI P.M., RANJBAR N., ABDULLAH R.C., WONG K.T., LEE G., IBRAHIM S., PARK C., YOON Y., JANG M., An efficient and economical treatment for batik textile wastewater containing high levels of silicate and organic pollutants using a sequential process of acidification, magnesium oxide, and palm shell-based activated carbon application, J. Environ. Manage., 2016, 184, 229–239. DOI: 10.1016/j.jenvman.2016.09.066.
• [3] HEBBAR R.S., ISLOOR A.M., ZULHAIRUN A.K., ABDULLAH M.S., ISMAIL A.F., Efficient treatment of hazardous reactive dye effluents through antifouling polyetherimide hollow fiber membrane embedded with functionalized halloysite nanotubes, J. Taiwan Inst. Chem. Eng., 2017, 72, 244–252. DOI: 10.1016/j.jtice.2017.01.022.
• [4] JI Z., HE Y., ZHANG G., Treatment of wastewater during the production of reactive dyestuff using a spiral nanofiltration membrane system, Desal., 2006, 201, 255–266. DOI: 10.1016/j.desal.2006.06.002.
• [5] MADAN S., SHAW R., TIWARI S., TIWARI S.K., Adsorption dynamics of Congo red dye removal using ZnO functionalized high silica zeolitic particles, Appl. Surf. Sci., 2019, 487, 907–917. DOI: 10.1016/j.apsusc.2019.04.273.
• [6] UNLU M., YUKSELER H., YETIS U., Indigo dyeing wastewater reclamation by membrane-based filtration and coagulation processes, Desal., 2009, 240, 178–185. DOI: 10.1016/j.desal.2008.02.026.
• [7] LIANG J., NING X.A., SUN J., SONG J., HONG Y., CAI H., An integrated permanganate and ozone process for the treatment of textile dyeing wastewater. Efficiency and mechanism, J. Clean. Prod., 2018, 204, 12–19. DOI: 10.1016/j.jclepro.2018.08.112.
• [8] ANUSHREE C., PHILIP J., Efficient removal of methylene blue dye using cellulose capped Fe3O4 nanofluids prepared using oxidation-precipitation method, Colloids Surfaces A Phys. En., 2019, 567, 193–204. DOI: 10.1016/j.colsurfa.2019.01.057.
• [9] LIN J., TANG C.Y., YE W., SUN S.-P., HAMDAN S.H., VOLODIN A., HAESENDONCK C.V., SOTTO A., LUIS P., BRUGGEN B.V.D., Unraveling flux behavior of superhydrophilic loose nanofiltration membranes during textile wastewater treatment, J. Mem. Sci., 2015, 493, 690–702. DOI: 10.1016/j.memsci.2015.07.018.
• [10] MULYANTI R., SUSANTO H., Wastewater treatment by nanofiltration membranes, IOP Conf. Ser. Earth Environ. Sci., 2018, 142, 1. DOI: 10.1088/1755-1315/142/1/012017.
• [11] SUN S.P., HATTON T.A., CHAN S.Y., CHUNG T.-S., Novel thin-film composite nanofiltration hollow fiber membranes with double repulsion for effective removal of emerging organic matters from water, J. Mem. Sci., 2012, 401–402, 152–162. DOI: 10.1016/j.memsci.2012.01.046.
• [12] BABU J., MURTHY Z.V.P., Treatment of textile dyes containing wastewaters with PES/PVA thin film composite nanofiltration membranes, Sep. Purif. Technol., 2017, 183, 66–72. DOI: 10.1016/j. seppur.2017.04.002.
• [13] AOUNI A., FERSI C., CUARTAS-URIBE B., BES-PIA A., ALCAINA-MIRANDA M.I., DHAHBI M., Reactive dyes rejection and textile effluent treatment study using ultrafiltration and nanofiltration processes, Desalin., 2012, 297, 87–96. DOI: 10.1016/j.desal.2012.04.022.
• [14] WANG X., GAO X., ZHANG Y., WANG X., GAO C., Batik effluent reclamation through a task-orientated coupling process of nanofiltration membranes, Desalin. Water Treat., 2016, 57, 27557–27572. DOI: 10.1080/19443994.2016.1186566.
• [15] BHUIYAN M.S.H., MIAH M.Y., PAUL S.C., AKA T.D., SAHA O., RAHAMAN M.Z., SHARIF M.J.I., HABIBA O., ASHADUZZAMAN M., Green synthesis of iron oxide nanoparticle using Carica papaya leaf extract: application for photocatalytic degradation of remazol yellow RR dye and antibacterial activity, Heliyon., 2020, 6, e04603. DOI: 10.1016/j.heliyon.2020.e04603.
• [16] CHOWDHURY M.F., KHANDAKER S., SARKER F., ISLAM A., RAHMAN T., AWUAL M.R., Current treatment technologies and mechanisms for removal of indigo carmine dyes from wastewater. A review, J. Mol. Liq., 318, 114061. DOI: 10.1016/j.molliq.2020.114061.
• [17] ISTIROKHATUN T., DEWI M.N., ILMA H.I., SUSANTO H., Separation of antiscalants from reverse osmosis concentrates using nanofiltration, Desalin., 2018, 429, 105–110. DOI: 10.1016 /j.desal. 2017.12.018.
• [18] Standard Methods, 5220 Chemical Oxygen Demand (COD) (2017) in Standard Methods for the Examination of Water and Wastewater, 2017.
• [19] RASHIDI H.R., SULAIMAN N.M.N., HASHIM N.A., HASSAN C.R.C., RAMLI M.R., Synthetic reactive dye wastewater treatment by using nano-membrane filtration, Desalin. Water Treat., 2015, 55, 86–95. DOI: 10.1080/19443994.2014.912964.
• [20] HEJASE C.A., TARABARA V.V., Nanofiltration of saline oil-water emulsions: Combined and individual effects of salt concentration polarization and fouling by oil, J. Mem. Sci., 2021, 617, 118607. DOI: 10.1016/j.memsci.2020.118607.
• [21] WEINMAN S., Development of Anti-fouling Membranes for Water Treatment, Ph.D. Thesis, Clemson University, 2018.
• [22] KASIM N., MOHAMMAD A.W., ABDULLAH S.R.S., Characterization of hydrophilic nanofiltration and ultrafiltration membranes for groundwater treatment as potable water resources, Desalin. Water Treat., 2016, 57, 7711–7720. DOI: 10.1080/19443994.2015.1054891.
• [23] ZHANG R., SU Y., ZHAO X., LI Y., ZHAO J., JIANG Z., A novel positively charged composite nanofiltration membrane prepared by bio-inspired adhesion of polydopamine and surface grafting of poly(ethylene imine), J. Mem. Sci., 2014, 470, 9–17. DOI: 10.1016/j.memsci.2014.07.006.
• [24] UZAL N., YILMAZ L., YETIS U., Nanofiltration and reverse osmosis for reuse of indigo dye rinsing waters, Sep. Sci. Technol., 2010, 45, 331–338. DOI: 10.1080/01496390903484818.
• [25] TILAK B.D., Naphthoquinonoid dyes and pigments, [In:] K. Venkataraman (Ed.), The Chemistry of Sythetic Dyes, Academic Press, New York 1971, 1–55.