PL EN


Preferencje help
Widoczny [Schowaj] Abstrakt
Liczba wyników
2017 | Vol. 43, nr 3 | 247--254
Tytuł artykułu

Treatment of effluent (skim latex serum) from a rubber processing plant with Fenton’s reagent

Treść / Zawartość
Warianty tytułu
Języki publikacji
EN
Abstrakty
EN
The treatment effectiveness of Fenton's reagent using Fe2+catalyst to reduce chemical oxygen demand (COD) of skim latex serum and the effect of varying concentrations of H2O2, Fe2+and initial solution pH on its treatment efficiency were investigated. The highest COD removal efficiency obtained was approximately 80% at optimum conditions. The treatment required either nominal or no acidification as initial pH of serum is very close to the optimum pH = 4. COD removal increased upon increasing H2O2 and Fe2+concentrations. This study shows the suitability of using Fenton's process with H2O2and FeCh as a pre-Treatment for skim latex serum. The findings reported here represent a potentially simpler and more cost-effective alternative treatment to other treatment methods since only reagents and not capital-intensive materials (such as membrane) are required.
Wydawca

Rocznik
Strony
247--254
Opis fizyczny
Bibliogr. 22 poz., tab., rys.
Twórcy
autor
  • Faculty of Chemical Engineering, Universiti Teknologi Mara, Shah Alam, Selangor; 40450, Malaysia
  • Chemical Engineering Department, King Saud University, Riyadh; 11421, Saudi Arabia
autor
  • Faculty of Chemical Engineering, Universiti Teknologi Mara, Shah Alam, Selangor; 40450, Malaysia
Bibliografia
  • [1] KONGJAN P., JARIYABOON R., SOMPONG O., Anaerobic digestion of skim latex serum (SLS) for hydrogen and methane production using a two-stage process in a series of up-flow anaerobic sludge blanket (UASB) reactor, Int. J. Hydr. En., 2014, 39 (33), 19343.
  • [2] JAWJIT W., PAVASANT P., KROEZE C., Evaluating environmental performance of concentrated latex production in Thailand, J. Cleaner Prod., 2013, 98, 84.
  • [3] MOHAMMADI M., MAN H.C., HASSAN M.A., YEE P.L., Treatment of wastewater from rubber industry in Malaysia, African J. Biotechnol., 2013, 9 (38), 6233.
  • [4] IDRIS J., MD SOM A., MUSA M., KU HAMID K., HUSEN R., RODHI M., NAJWA M., Dragon fruit foliage plant-based coagulant for treatment of concentrated latex effluent: comparison of treatment with ferric sulfate, J. Chem., 2013, ID 230860.
  • [5] ABDUL-KADIR M.O., ISMAIL N., ABLLA N., ABDUL RAHMAN N., Use of natural bacteria to accelerate the extended aeration treatment of processed latex effluent, J. Rubber Res., 2000, 3, 34.
  • [6] ISA Z., Waste from rubber processing and rubber product manufacturing industries, [in:] B.G. Yeoh, K.S. Chee, S.M. Phang, Z. Isa, A. Idris, M. Mohamed (Eds.), Waste Management in Malaysia. Current Status and Prospects for Bioremediation, Ministry of Science and Technology, Kuala Lumpur 1993, 137.
  • [7] SETHU S., Ion-exchange membranes. Spplication to the treatment of natural rubber skim latex, J. Appl. Poly. Sci., 1964, 8, 2249.
  • [8] SUWANDI M.S., LEFEBVRE M.S., Performance of fractal membranes in the ultrafiltration of skim natural rubber latex, Desalination, 1988, 70, 225.
  • [9] HARUNSYAH SULAIMAN N.M.N., AROUA M.K., Cake layer reduction by gas sparging cross flow ultrafiltration of skim latex serum, Songklanakarin J. Sci. Technol., 2002, 24, 947.
  • [10] JAYACHANDRAN K., SURESH P.V., CHANDRASEKARAN M., A novel Acinetobacter sp. for treating highly acidic rubber latex centrifugation effluent, Biotechnol. Lett., 1994, 16, 649.
  • [11] CHOORIT W., THANAKOSET P., THONGPRADISTHA J., SASAKI K., NOPARATNARAPORN N., Identification and cultivation of photosynthetic bacteria in wastewater from a concentrated latex processing factory, Biotechnol. Lett., 2002, 24, 1055.
  • [12] SANZ J., LOMBRANA J.I., DELUIS A.M., ORTUETA M., VARONA F., Microwave and Fenton’s reagent oxidation of wastewater, Environ. Chem. Lett., 2003, 1, 45.
  • [13] WALLING C., Fenton’s reagent revisited, Acc. Chem. Res., 1975, 8, 125.
  • [14] XU X.R., LI H.B., WANG W.H., GU J.D., Degradation of dyes in aqueous solutions by the Fenton process, Chemosphere, 2004, 57, 595.
  • [15] ALATON I.A., TEKSOY S., Acid dyebath effluent pretreatment using Fenton’s reagent. Process optimization, reaction kinetics and effects on acute toxicity, Dyes Pigm., 2007, 73, 31.
  • [16] VIONE D., MERLO F., MAURINO V., MINERO C., Effect of humic acids on the Fenton degradation of phenol, Environ. Chem. Lett., 2004, 2, 129.
  • [17] ZHANG H., HEONG J.C., HUANG C.P., Treatment of landfill leachate by Fenton’s reagent in a continuous stirred tank reactor, J. Hazard. Matter, 2006, 136, 618.
  • [18] BELTRAN F.J., GONZALEZ M., RIBAS F.J., ALVAREZ P., Fenton reagent advanced oxidation of polynuclear aromatic hydrocarbons in water, Water Soil Air Poll., 2004, 105, 685.
  • [19] Department of Environment (DOE), Malaysia, Environmental quality. Sewage and Industrial Effluent, Regulation 1979, Third Schedule Environmental Quality Act, 1974, 2011.
  • [20] BIGDA R.J., Consider Fenton’s chemistry for wastewater treatment, Chem. Eng. Progr., 1995, 91, 62.
  • [21] KANG Y.W., HWANG K.Y., Effects of reaction conditions on the oxidation efficiency in the Fenton process, Water Res., 2000, 34, 2786.
  • [22] PIGNATELLO J.J., OLIVEROS E., MACKAY A., Advanced oxidation processes for organic contaminant destruction based on the Fenton reaction and related chemistry, Crit. Rev. Environ. Sci. Technol., 2006, 36, 1.
Typ dokumentu
Bibliografia
Identyfikatory
Identyfikator YADDA
bwmeta1.element.baztech-a20a5349-229d-4ff6-87a6-f1483918b3cd
JavaScript jest wyłączony w Twojej przeglądarce internetowej. Włącz go, a następnie odśwież stronę, aby móc w pełni z niej korzystać.